Littlejohn HVAC Solutions is a licensed, insured HVAC contractor in Asheboro, NC, run by owner Jesse Littlejohn out of Burlington, about 55 minutes north. We fold Asheboro calls into planned Randolph County routes, handle AC, gas furnace, heat pump and ductwork jobs, and put a free written estimate in your hands before any work starts.
Your local HVAC contractor for Asheboro, NC
Most people outside Randolph County know Asheboro for the North Carolina Zoo. People who live here know it for the hills, the Sunset Avenue storefronts downtown and the neighborhoods built when hosiery and furniture plants kept the town busy. Those neighborhoods are where much of our Asheboro work happens.
The drive from Burlington runs about 55 minutes, so we don't pretend to be around the corner. We group Asheboro calls into planned routes and set real arrival windows, which keeps the distance from turning into a long wait. Same-day service is possible on most calls, and we call ahead when we're on the way.
Mid-Century Asheboro Homes and Tired Ductwork
A lot of Asheboro's housing went up between the late 1940s and the 1970s: brick ranches, split-levels and small frame houses on sloped lots. Many were built for a single furnace with a short supply trunk. Air conditioning got added later, often with the original ducts left in place.
That leaves a system moving more air than the metal was sized for. You see it as a back bedroom that never cools, a register that whistles and a blower motor straining against high static pressure. On sloped lots the crawlspace is often damp on the downhill side, so duct wrap sags, seams rust and the return pulls in musty air.
Before recommending new equipment, we measure static pressure and check duct sizing. Sometimes a larger return and resealed joints fix the comfort problem outright. When the trunk line is undersized or falling apart, ductwork replacement sized with a load calculation is the better investment than a bigger outdoor unit.
Where We Work Around Asheboro
Calls come from the older streets near downtown and Fayetteville Street, from the neighborhoods along Dixie Drive, from newer homes out US-64 and around Lake Lucas west of town, and from the Zoo side of Asheboro to the southeast. We also cover rural addresses heading south toward the Uwharries, where houses sit farther apart and a heat pump is often the only heat source.
A common Asheboro call in July goes like this: the upstairs of a split-level sits at 80 degrees while the thermostat says 74. The unit is running, but the evaporator coil is caked with dust because the filter slot doesn't seal and the return is half the size it should be. Cleaning the coil helps that day. Fixing the return keeps it from coming back.
In winter, the typical call is an older gas furnace that lights and then shuts off after a few seconds. More often than not it's a dirty flame sensor or a weak draft inducer, and we show homeowners what we found before touching anything else.
HVAC by home type in Asheboro
Three kinds of Asheboro homes account for most of our service calls, and each fails in its own way.
Post-war brick ranches on sloped lots
Crawlspace-ducted furnace or heat pump
Here the equipment is often fine; the air it breathes is not. Panned joist-bay returns pull from the damp downhill corner and coat the blower wheel in dust. We replace panned returns with sealed metal and add a crawlspace vapor barrier when the dirt stays wet.
1960s and 70s split-levels
Zoned ducts or a ductless head upstairs
Split-levels put bedrooms half a floor above the air handler, and summer heat climbs straight to them. One thermostat on the middle level never feels the upper rooms. Zoning, or a single ductless mini-split head upstairs, fixes it without tearing into the finished den on the lower level.
Rural homes on acreage toward the Uwharries
Heat pump with properly sized electric backup
Past the edge of town, many houses heat with a heat pump alone. A burned-out strip element, a tripped backup breaker or a misconfigured outdoor thermostat leaves them chilly on the first hard freeze. We check each strip's amp draw during fall heat pump service each October.
Common HVAC problems in Asheboro homes
Asheboro's hills and housing age make these repairs more likely.
| Problem | Why it happens in Asheboro | What we do |
|---|---|---|
| Blower motors wearing out years before they should | Undersized mid-century returns make the motor fight high static pressure every hour it runs. | Jesse checks amp draw and static, replaces the motor or capacitor, then corrects the return. |
| Rust forming on furnace burners and cabinet floors | Furnaces set low in damp downhill crawlspaces sit in humid air year-round. | We clean burners, inspect the heat exchanger and flue, and check drainage around the unit. |
| Refrigerant leaks in long line sets across yards | Runs across hillside yards get pinched as pads settle or nicked by string trimmers. | We locate the leak, repair it, pull a deep vacuum and weigh in the charge. |
| Big temperature swings between upper and lower levels | Split-levels and walkout basements on Asheboro slopes share one thermostat across unequal heat loads. | We measure register airflow, set balancing dampers and discuss zoning if balancing falls short. |
HVAC services in Asheboro, NC
These are the services Asheboro homeowners ask for most, based on the age of the housing and the way the terrain affects crawlspaces and duct runs:
Ductwork Installation & Repair
Complete duct system installation and replacement for crawlspaces and attics, designed for real airflow so every room gets the air it should.
Learn moreAC Repair
Honest air conditioner diagnosis and repair, often the same day. We find the actual failed part and fix it instead of pushing a new unit.
Learn moreFurnace & Heating Repair
Gas and electric furnace repair that traces the ignition sequence step by step, with safety checks on venting and the heat exchanger every time.
Learn moreHeat Pump Services
Repair, replacement and tune-ups for the heat pumps that heat and cool most Burlington homes, including defrost, reversing valve and backup heat issues.
Learn moreHVAC Installation & Replacement
New AC, furnace and heat pump systems sized with a real load calculation, installed cleanly, and explained in writing before any work begins.
Learn more
Why Asheboro residents choose Littlejohn HVAC Solutions
Asheboro sits near the outer edge of our roughly 50-mile service radius, so we earn the trip by getting the diagnosis right the first time. Here's what that looks like on Asheboro's hills.
Routes planned around a 55-minute drive
We don't run one truck down and back for a single Asheboro call if we can help it. Calls get grouped with Randleman and Ramseur stops, you get a real window based on that day's route, and Jesse calls once he's on the road.
The wet downhill side of the crawlspace
On Asheboro's sloped lots, the downhill corner of the crawlspace is where duct wrap sags and returns pick up musty air. We check that corner first and can add a crawlspace vapor barrier when moisture is feeding the duct problem.
Static pressure before any sales pitch
Many 1950s–70s ranches and split-levels here have a return half the size the blower needs. We measure static pressure against the blower's rating, so you know whether a bigger return or a new trunk line fixes that hot back bedroom.
Rural heat pumps toward the Uwharries
South of town, a heat pump is often the only heat in the house. When one quits on a frosty night, we answer 24/7 for emergencies and tell you honestly how soon we can get down there, instead of quoting a time the drive can't support.
A year of HVAC in Asheboro
Spring
Pine and oak pollen drifts across Asheboro's wooded hills every April and mats onto outdoor coils. Rinse the condenser from the inside out, change filters more often, and get the charge checked before the first 90-degree week.
Summer
Afternoon thunderstorms and power blips are rough on capacitors and contactors, so a unit that hums but won't start after a storm is a frequent July call. Keep grass clippings and shrubs back from the condenser.
Fall
Get the heat checked before the first cold snap: flame sensor, inducer and limit switch on gas furnaces, defrost and backup strips on heat pumps. October is also the comfortable month for crawlspace duct work.
Winter
Winters here are mostly mild, with a few hard freezes and the odd ice storm. When power returns after an outage on rural Randolph County roads, wait a few minutes before restarting and call if emergency heat won't engage.
Serving Asheboro from Burlington
Littlejohn HVAC Solutions, LLC is a service-area business based in Burlington, NC 27217. We come to you — about 55 minutes from our Burlington base.